Performance of an enzymatic packed bed reactor running on babassu oil to yield fatty ethyl esters (FAEE) in a solvent-free system

Document Type : Research Paper

Authors

1 Engineering School of Lorena, University of São Paulo Estrada Municipal do Campinho s/n, 12602-810 Lorena, São Paulo, Brazil.

2 State University of Maringa, Department of Chemical Engineering, Av. Colombo 5790, E-46, 87020-900, Maringa – PR, Brazil.

Abstract

The transesterification reaction of babassu oil with ethanol mediated by Burkholderia cepacia lipase immobilized on SiO2-PVA composite was assessed in a packed bed reactor running in the continuous mode. Experiments were performed in a solvent-free system at 50 °C. The performance of the reactor (14 mm ×210 mm) was evaluated using babassu oil and ethanol at two molar ratios of 1:7 and 1:12, respectively, and operational limits in terms of substrate flow rate were determined. The system’s performance was quantified for different flow rates corresponding to space times between 7 and 13 h. Under each condition, the impact of the space time on the ethyl esters formation, the transesterification yield and productivity were determined. The oil to ethanol molar ratio was found as a critical parameter in the conversion of babassu oil into the correspondent ethyl esters. The highest transesterification yield of 96.0 ± 0.9% and productivity of 41.1 ± 1.6 mgester gcatalyst-1h-1 were achieved at the oil to ethanol molar ratio of 1:12 and for space times equal or higher than 11 h. Moreover, the immobilized lipase was found stable with respect to its catalytic characteristics, exhibiting a half-life of 32 d.

Graphical Abstract

Performance of an enzymatic packed bed reactor running on babassu oil to yield fatty ethyl esters (FAEE) in a solvent-free system

Keywords


Antczak, M.S., Kubiak, A., Antczak, T., Bielecki, S., 2009. Enzymatic biodiesel synthesis – Key factors affecting efficiency of the process. Renew. Energy. 34, 1185-1194.
Balcão, V.M., Paiva, A.L., Malcata, F.X., 1996.  Bioreactors with immobilized lipases: State of the art. Enzyme Microb. Technol. 18, 392-416.
Brunschwig, C., Moussavou, W., Blin, J., 2012. Use of bioethanol for biodiesel production. Prog. Energ. Combust.38, 283-301.
Carvalho, A.K.F., Da Rós, P.C.M., Teixeira, L.F., Andrade, G.S.S., Zanin, G.M., De Castro, H.F., 2013. Assessing the potential of non-edible oils and residual fat to be used as a feedstock source in the enzymatic ethanolysis reaction. Ind. Crop. Prod. 50, 485-493. 
Christopher, L.P., Kumar, H., Zambare, V.P., 2014. Enzymatic biodiesel: Challenges and  opportunities. Appl. Energ. 119, 497-520. 
Costa-Silva, W., Teixeira, L.F., Carvalho, A.K.F., Mendes, A.A., De Castro, H.F., 2014.  Influence of feedstock source on the biocatalyst stability and reactor performance in continuous biodiesel production. J. Ind. Eng. Chem.20, 881-886.
Da Rós, P.C.M., Silva, G.A.M., Mendes, A.A., Santos, J.C., De Castro, H.F., 2010. Evaluation of the catalytic properties of Burkholderia cepacia lipase immobilized on non-commercial matrices to be used in biodiesel synthesis from different feedstocks. Bioresour. Technol. 101, 5508-5516.
Damstrup, M.L., Kill, S., Jensen, A.D., Sparso, F.V., Xu, X., 2007. Process development of continuous glycerolysis in an immobilized enzyme-packed reactor for industrial monoacylglycerol production. J. Agric. Food Chem. 55, 7786-7792. 
Dors, G., Freitas, L., Mendes, A.A., Furigo Jr, A., De Castro, H.F., 2012. Transesterification of palm oil catalyzed by Pseudomonas fluorescens lipase in a packed- bed reactor. Energ Fuel. 26, 5977-5982.  
Dossat, V., Combes, D., Marty, A., 1999. Continuous enzymatic transesterification of high oleic sunflower oil in a packed bed reactor: influence of the glycerol production. Enzyme Microb. Technol.25, 194-200.
Fogler, H.S., 1992. Elements of chemical reaction engineering.Prentice Hall: Englewood Cliffs, NJ.
Fox, R.W., Pritchard, P.J., McDonald, A.T., 2013.  Introdução à mecânica dos fluídos, (7th ed.). Tradução e Revisão Técnica: Koury, R.N.M., Machado, L. Rio de Janeiro: LTC.
Freitas, L., Da Rós, P.C.M., Santos, J.C., De Castro, H.F., 2009. An integrated approach to produce biodiesel and monoglycerides by enzymatic interesterification of babassu oil (Orbinya sp.). Process Biochem. 44, 1068-1074.
Freitas, L., Silva, G.S., Santos, J.C., Oliveira, P.C., De Castro, H.F., 2011. Strategies to remove water formed as by-product on the monoolein synthesis by enzymatic esterification performed on packed bed reactor. Eur. Food Res. Technol. 233, 743-750.
Halim, S.F.A., Kamaruddin, A.H., Fernando, W.J.N., 2009. Continuous biosynthesis of biodiesel from waste cooking palm oil in a packed bed reactor: Optimization using response surface methodology (RSM) and mass transfer studies. Bioresour. Technol. 100, 710-716.
Hama, S., Tamalampudi, S., Yoshida, A., Tamadani, N., Kuratani, N., Noda, H., Fukuda, H., Kondo, A., 2011. Process engineering and optimization of glycerol separation in a packed-bed reactor for enzymatic biodiesel production. Bioresour. Technol.102, 10419-10424.
Levenspiel, O., 1972. Chemical Reaction Engineering, 2nd ed., John Wiley, New York.
Lide, D.R., 2006. Definition of scientific terms. In Handbook of Chemistry and Physics, (87th ed.). CRC Press: Boca Raton, FL.
Jegannathan, K.R., Abang, S.A., Poncelet, D., Chan, E.S., Ravindra, P., 2008. Production of biodiesel using immobilized lipase—a critical review.  Crit. Rev. Biotechnol. 28, 253-264.
Kawakami, K., Oda,Y., Takahashi, R., 2011. Application of a Burkholderia cepacia lipase immobilized on silica monolith to batch and continuous biodiesel production with a stoichiometric mixture of methanol and crude Jatropha oil. Biotechnol. Biofuels. 42, 1-11. 
Ricca, E., Paola, M.G., Calabro, V., Curcio, S., Iori, G., 2009. Olive husk oil transesterification in a fluidized bed reactor with immobilized lipases. Asian Pac. J. Chem. Eng. 4, 365-368.
Royon, D., Daz, M., Ellenrieder, G., Locatelli, S., 2007. Enzymatic production of biodiesel from cotton seed oil using t-butanol as a solvent. Bioresour. Technol. 98, 648-653.
Soares, C.M.F., De Castro, H.F., De Moraes, F.F., Zanin, G.M., 1999. Characterization and utilization of Candida rugosa lipase immobilized on controlled pore silica. Appl. Biochem. Biotechnol. 79, 745-757.
Stamenkovic, O.S., Velickovic, A.V., Veljkovic, B.V., 2011. The production of biodiesel from vegetable oils by ethanolysis: Current state and perspectives. Fuel.90, 3141-3155.
Teixeira, M.A., 2008. Babassu—A new approach for an ancient Brazilian biomass. Biomass Bionerg. 32, 857-864.
Urioste, D., Castro, M.B.A., Biaggio, F.C., De Castro, H.F., 2008. Synthesis of chromatographic standards and establishment of a method for the quantification of the fatty ester composition of biodiesel from babassu oil. Quim. Nova. 31, 407-412.
Yusuf, C. Bioreactor design. In: Ratledge, C., Kristiansen, B., 2006. Basic Biotechnology,( 3 ed.) Cambridge: Cambridge University Press, pp. 181-200.
Watanabe, Y., Shimada, Y., Sugihara, A., Noda, H., Fukudac, H., Tominaga, Y., 2000. Continuous production of biodiesel fuel from vegetable oil using immobilized Candida antarctica lipase. J. Am. Oil Chem. Soc. 77, 355-360.
Zanin, G.M., Moraes, F.F., 2004. Enzimas Imobilizadas. In: Said, S., Pietro, R.C.L.R. Enzimas como agentes biotecnológicos. Ribeirão Preto: Legis Summa,. pp. 35-85.