Evaluation of the cultivation conditions of marine microalgae Chlorella sp. to be used as feedstock in ultrasound-assisted ethanolysis

Document Type : Research Paper

Authors

1 Engineering School of Lorena-University of São Paulo, Lorena, SP, Brazil.

2 Engineering Faculty of Guaratingueta – State University Julio de Mesquita Filho-UNESP, Guaratingueta, SP, Brazil.

3 Department of Bioproducts and Biosystems Engineering, College of Food, Agricultural and Natural Resource Sciences, University of Minnesota, USA.

Abstract

A total of 8 assays was conducted to study the influence of different variables namely, light intensity, CO2 level, NaNO3 concentration and aeration rate, on the cultivation of the marine microalgae Chlorella sp. to enhance the biomass feedstock availability for biodiesel. The experiments were designed using a Taguchi L8 experimental array set at two levels of operation, having light intensity (0.85 and 14.5 klux), CO2 (5 and 10%), NaNO3 (0.025 and 0.075 g L-1) and aeration rate (3:33 and 1.67 vvm) as independent variables and considering biomass productivity and lipid content as response variables. All the experiments were performed in six photobioreactor vessels connected in series with a total volume of 8.4 L and working volumes of 2 L and 4 L, depending on the conditions assessed. The highest biomass productivity was 210.9 mg L-1day-1, corresponding to a lipid content of 8.2%. Such results were attained when the culture conditions were set at 0.85 klux light intensity, 5% CO2 and 0.075 g L-1 NaNO3. The aeration rate showed no significant influence on the biomass productivity. On the other hand, the highest lipid content was achieved when the cultures were grown using the lowest concentration of NaNO3 (0.025 g L-1) and an aeration rate of 1.67 vvm, while the other factors had no statistical significance. Under these conditions, the lipid content obtained was 19.8%, at the expense of reducing the biomass productivity to 85.9 mg L-1day-1.The fatty acid profile of the lipid material characterized by gas chromatography identified fourteen fatty acids with carbon chain ranging from C8 to C20 in which most of the fatty acids present were saturated (58.7 %) and monounsaturated (36.1%) fatty acids. Those obtained at higher proportions were the oleic (22.8%), palmitic (20.7%) and lauric (17.7 %) acids, indicating a suitable composition for fatty acid ethyl esters (FAEE) synthesis. This was confirmed by acid catalysis performed under ultrasound irradiations reaching a conversion rate of 78.4% within only 4 h.

Graphical Abstract

Evaluation of the cultivation conditions of marine microalgae Chlorella sp. to be used as feedstock in ultrasound-assisted ethanolysis

Keywords


American Oil Chemists’ Society, 2004. Official Methods and Recommended Practices of the AOCS,5th ed., Champaign: AOCS.
Beetul, K., Sadally, S.B., Taleb-Hossenkhan, N., Bhagooli, R., Puchooa, D., 2014. An   investigation of  biodiesel production from microalgae found in mauritian waters. Biofuel Res. J. 2, 58-64.
Bligh, E.G., Dyer, W.J., 1959. A rapid method of total lipid extraction and purification. Can. J. Biochem. Physiol. 37, 911-917.
Chisti, Y., 2007. Biodiesel from microalgae. Biotechnol. Adv. 25, 294-306.
Da Rós, P.C.M., Silva, C.S.P., Silva-Stenico, M.E., Fiore, M.F., de Castro, H.F., 2013. Assessment of chemical and physico-chemical properties of cyanobacterial lipids for biodiesel production. Mar. Drugs. 11, 2365-2381.
D’oca, M.G.M., Haertel, P.L., Moraes, D.C., Callegaro, F.J.P., Kurz, M.H.S., Primel, E.G., Clementin, R.M., Morón-Villarreyes, J.A., 2011a. Base/acid-catalyzed FAEE production from hydroxylated vegetable oils. Fuel. 99, 912-916.
D’oca, M.G.M., Viêgas, C.V., Lemões, J.S., Miyasaki, E.K., Morón-Villarreyes, J.A., Primel, E.G., Abreu, P.C., 2011b. Production of FAMEs from several microalgal lipidic extracts and direct transesterification of the Chlorella pyrenoidosa. Biomass Bioenergy. 35, 1533-1538.
Ehimen, E.A., Sun, Z.F., Carrington, C.G, 2010. Variables affecting the in situ transesterification of microalgae lipids. Fuel. 89, 677-684.
Francisco, E.C., Neves, D.B., Jacob-Lopes, E., Franco, T.T., 2010. Microalgae as feedstock for biodiesel production: Carbon dioxide sequestration, lipid production and biofuel quality. J. Chem. Technol. Biotechnol. 85, 395-403.
Girard, J.M., Roy, M.-L., Hafsa, M.B., Gagnon, J., Faucheux, N., Heitz, M., Tremblay, R., Deschênes, J.S., 2014. Mixotrophic cultivation of green microalgae Scenedes musobliquus on cheese whey permeate for biodiesel production. Algal Res. 5, 241-248.
Guillard, R.R.L., 1975. Culture of phytoplankton for feeding marine invertebrates, In: Smith W.L., Chanley, M.H., Culture of Marine Invertebrate Animals, New York: Plenum, pp. 29-60.
Gushina, L.A., Harwood, J.L., 2006. Lipids and lipid metabolism in eukaryotic algae. Prog. Lipid Res. 45, 160-185.
Huntley, M.E., Redalje, D.G., 2007. CO2 mitigation and renewable oil from photosynthetic microbes: a new appraisal. Mitig. Adapt. Strat. Gl. 12, 573-608.
Knothe, G., 2005. Dependence of biodiesel fuel properties on the structure of fatty acid alkyl esters. Fuel Process. Technol. 86, 1059-1070.
Koller, M., Muhr, A., Braunegg, G., 2014. Microalgae as versatile cellular factories for valued products. Algal Res. 6, 52-63.
Lam, M.K., Lee, K.T., 2013. Effect of carbon source towards the growth of Chlorella vulgaris for CO2 bio-mitigation and biodiesel production. Int. J. Greenh. Gas. Con. 14, 169-176.
Mata, T.M., Martins, A.A., Caetano, N.S., 2010. Microalgae for biodiesel production and other applications: A review. Renew. Sustain. Energy Rev. 14, 217-232.
Meng, X., Yang, J., Xu, X., Zhang, L., Nie, Q., Xian, M., 2009. Biodiesel production from oleaginous microorganisms. Renew. Energy. 34, 1-5.
Millán-Oropeza, A., Torres-Bustillos L.G., Fernández-Linares L., 2015. Simultaneous effect of nitrate (NO3-) concentration, carbon dioxide (CO2) supply and nitrogen limitation on biomass, lipids, carbohydrates and proteins accumulation in Nannochloropsis oculata. Biofuel Res. J. 5, 215-221.
Nascimento, I.A., Cabanelas, I.T.D., dos Santos, J.N., Nascimento, M.A., Souza, L., Sansone, G., 2015. Biodiesel yields and fuel quality as criteria for algal-feedstock selection: Effects of CO2-supplementation and nutrient levels in cultures. Algal Res. 8, 53-60.
Paiva, E.J.M., Silva, M.L.C.P., Barboza, J.C.S., Oliveira, P.C., de Castro, H.F., Giordani, D.S., 2013. Non-edible babassu oil as a new source for energy production-a feasibility transesterification survey assisted by ultrasound. Ultrason. Sonochem. 20, 833-838.
Praveenkumar, R., Shameera, K., Mahalakshmi, G., Akbarsha, M.A., Thajuddin, N., 2012.  Influence of nutrient deprivations on lipid accumulation in a dominant indigenous microalga Chlorella sp., BUM11008. Evaluation for biodiesel production. Biomass Bioenergy. 37, 60-66.
Ramos, M.J., Fernández, C.M., Casas, A., Rodríguez, L., Pérez, Á., 2009. Influence of fatty acid composition of raw materials on biodiesel properties. Bioresour. Technol. 100, 261-268.
Ross, P.J., 1995. Taguchi techniques for quality engineering, 2nd edition, McGraw-HillProfessional, New York.
Sanchez, J.L.G., Perez, J.A.S., Camacho, F.G., Sevilla, J.M.F., Grima, E.M., 1996. Optimization of light and temperature for growing Chlorella sp using response surface methodology. Biotechnol. Tech. 10, 329-334.
Sharma, P., Verma, A., Sidhu, R.K., Pandey, O.P., 2005. Process parameter selection for strontium ferrite sintered magnets using Taguchi L9 orthogonal design. J. Mater. Process. Technol. 168, 147-151.
Silva, C.S.P., Silva-Stenico, M.E., Fiore, M.F., deCastro, H.F., Da Rós, P.C.M., 2014. Optimization of the cultivation conditions for Synechococcus sp. PCC7942 (Cyanobacterium) to be used as feedstock for biodiesel production. Algal Res. 3, 1-7.
Suali, E., Sarbatly, R., 2012. Conversion of microalgae to biofuel. Renew. Sustain. Energy Rev. 16, (2012)  4316-4342.
Teo, C.L., Jamaluddin, H., Zain, N.A.M., Idris, A., 2014. Biodiesel production via lipase catalyzed transesterification of microalgae lipids from Tetraselmis sp. Renew. Energy. 68, 1-5.
Wang, C., Yu, X., Li, H., Yang, J., 2013a. Nitrogen and phosphorus removal from municipal wastewater by the green alga Chlorella sp. J. Environ. Biol. 34, 421-425.
Wang, W., Zhou, W., Liu, J., Li, Y., Zhang, Y., 2013b. Biodiesel production from hydrolysate of Cyperus esculentus waste by Chlorella vulgaris. Bioresour. Technol. 136, 24-29.
Zhu, L., 2015. Biorefinery as a promising approach to promote microalgae industry: An innovative framework. Renew. Sustain. Energy Rev.41, 1376-1384.